Results 1 to 10 of 14
-
06-02-2008, 10:57 PM #1
- Join Date
- May 2007
- Posts
- 21
05 Rxt oil sensor goes off at 4,000rpm.
I recently replaced all 3 oil sensors and pump. Ski idles fine on the water but at 4,000 rpm the ski bogs and oil sensor goes off. I rebuilt the engine since my sc decided to go out on me. What can be causing the problem?
05 RXT
Riva air intake
solas 14/19
Riva intake grate
Riva SC impelor
R&D Sc washers.
R&D pump wedgeLast edited by ADAM12; 06-03-2008 at 12:26 AM.
-
06-03-2008, 05:53 AM #2
You need to check your oil pressure. Install a guage on the fitting at the rear of the head (1/4 npt fitting).
You replaced your oil pump but did you replace the pressure relief valve.
First thing is to be sure your oil pressure is ok.
Cold it should be ~80 psi at idle and any rpm
Warmed up, ~20-25 psi at idle and around 40 psi over 3000 rpm.
-
06-03-2008, 10:49 AM #3
My 06 RXT doing same thing. Dealer replaced motor over the winter due to supercharger failure. Got it back, right at 3500rpm oil light, code 1520, limp mode. They replaced a sensor last week, still doing it. Ski is at the dealer now, will let you know if they ever figure it out.
-
06-04-2008, 09:31 PM #4
- Join Date
- May 2007
- Posts
- 21
Ski is at the dealer now, will let you know if they ever figure it out.
thanks guys.
Out of town right now so I will get on it once I get back. Let me know what the dealer found out.Last edited by ADAM12; 06-04-2008 at 09:35 PM.
-
06-04-2008, 10:09 PM #5
- Join Date
- Jul 2007
- Posts
- 287
-
06-06-2008, 08:26 PM #6
- Join Date
- May 2007
- Posts
- 21
-
06-07-2008, 09:22 AM #7
did they replace both pumps? make sure your oil levels are correct.
-
06-22-2008, 05:50 PM #8
-
06-23-2008, 11:21 AM #9
Talked to them 06/18, they said they talked to Seadoo and they thought it was a wiring problem. Called today 06/23, they still dont have a clue. It looks like I may have to get Seadoo involved again (not that It got me anywhere last time).
-
07-02-2008, 08:51 PM #10
- Join Date
- May 2007
- Posts
- 21
What up guys,
Here is the dealer story now. They are telling me that the valve seat sleeve on the oil pump could be damaged do to over thightening. They said they are 95% sure that is the problem since one of the mechanics had the same issue on another ski. Let me also mention they replaced all the sensors over again just in case. I also asked what the oil pressure reading was and they did not check it. This does not sound right to me! If my oil pressure was ok would it be giving me this problem? They did not rebuild the engine originally. So they said they need to pull the engine out to get to the oil pump. What should I do?
parts
SD SDP valve seat sleeve $20.25
SD SDP valve-piston $16.25
labor $500.00
05 RXT
R&D air intake
solas 14/19
Riva intake grate
Riva SC impelor
R&D Sc washers.
R&D pump wedge
out of wrrntyLast edited by ADAM12; 07-07-2008 at 11:34 PM.
Thread Information
Users Browsing this Thread
There are currently 1 users browsing this thread. (0 members and 1 guests)
Similar Threads
-
05 rxt oil capacity?
By Greggpru in forum 4-Tec PerformanceReplies: 8Last Post: 06-18-2016, 06:29 AM -
05 RXT oil light came on for a second
By race24x in forum 4-Tec PerformanceReplies: 5Last Post: 06-21-2011, 10:24 PM -
05 RXT oil leak
By wavehummer in forum 4-Tec PerformanceReplies: 5Last Post: 06-01-2009, 05:39 PM -
'05 RXT-fuel sensor/error code
By Emtp3494 in forum 4-Tec PerformanceReplies: 0Last Post: 05-22-2008, 11:16 PM -
05 GPR Oil Sensor
By mavrick816 in forum Yamaha PWC Performance (2-stroke)Replies: 2Last Post: 03-04-2008, 03:00 PM
Yes, it has a channel down the middle. Here's a pic.
2015 FXHO-- Fish Finder and...