Results 1 to 4 of 4

Thread: 2012 ultra 300x

  1. #1

    2012 ultra 300x

    Surging , only after getting warm, after about 6 miles, let cool off, wot 4, about 3 miles then starts surging at all throttle position.
    Any advice? No fault codes!!!


  2. #2
    Spooling's Avatar
    Join Date
    Sep 2011
    Location
    West Coast of Florida
    Posts
    1,352
    +1
    190

    Maintenance

    Quote Originally Posted by Mikey N.C. View Post
    Surging , only after getting warm. Any advice? No fault codes!!!
    --------------------------
    There are a few things that should be checked before requesting additional advice - as all of these things have been covered over-and-over in redundancy on this Kawasaki Forum. You can search the archives for guys with similar symptoms and how such issues were alleviated.

    So with such being said - I will share with you some of these issues discovered which should enable you to get diagnosing right away.

    1. You can run the ski with the seats off - and even the rear section held on with (4) 10mm cone nuts. This will enable you to see if it is being "choked-out" with exhaust fumes - yet other models are certainly more suseptible to this issue.

    2. With the seats off - maybe even better with the ski strapped to the trailer and in the water a good ways - look for water leaking around the driveshaft bearing holder - and possibly spraying on the Supercharger Belt - which would cause slippage.

    3. Let us know what the Boost Gauge is doing during this time - probably bouncing up and down?

    4. Probably time to conduct the following Maintenance Assignment to the Supercharger Drive Belt Tensioner:

    http://greenhulk.net/forums/showthre...=1#post2655153

    5. Certainly inspect to see if your Exhaust Filter is still intact and if it's gone - it could be trying to exit out the exhaust hose - plugging the exhaust flow - and possibly allowing exhaust fumes into the hull via a cut hose - which could result in an even more serious issue - namely taking on water and flooding the engine compartment.

    Reference:

    http://greenhulk.net/forums/showthread.php?t=221364

    Good Luck !!!

  3. #3
    Ran 2 nd time yesterday without seat, pulled drain plugs no water.
    Would SC belt tensioner only act up after 5-6 miles ?
    I checked primary & secondary on coils the 2-3 coil primary resistance was all over the place 10-16-8-4-12 ohms 1-4 coil dead on 2.4, let ski cool off, 2-3 coil at 2.9. Ski ran great till it got hot, checked primary on coil again and same thing so ordering a coil and see

  4. #4
    Oh thanks for info

Thread Information

Users Browsing this Thread

There are currently 1 users browsing this thread. (0 members and 1 guests)

Similar Threads

  1. kawasaki ultra 300x 2012
    By kaw300x77 in forum Kawasaki How To & FAQs
    Replies: 8
    Last Post: 06-13-2019, 01:55 AM
  2. 2012 Ultra 300x just purchased
    By danzr in forum 4-Tec Performance
    Replies: 5
    Last Post: 06-28-2018, 02:33 PM
  3. Ultra 300x 2012 mods
    By yld-nyt in forum Kawasaki How To & FAQs
    Replies: 4
    Last Post: 12-04-2013, 01:12 AM
  4. Kawasaki ultra 300x 2012
    By denmark007 in forum Kawasaki PWC Performance (4-stroke)
    Replies: 12
    Last Post: 07-15-2013, 09:03 PM
  5. Ultra 300x 2012 vs 2013
    By ronaldsons in forum Kawasaki PWC Performance (4-stroke)
    Replies: 8
    Last Post: 12-11-2012, 11:14 PM

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •