Search

Type: Posts; User: Myself

Page 1 of 8 1 2 3 4

Search: Search took 0.03 seconds.

  1. Replies
    9
    Views
    129

    That's great output voltage of the excitor....

    That's great output voltage of the excitor.
    What's your DC voltage on the brown wire out of the cdi while cranking? Should be around 8. Meter on VDC.
  2. Replies
    3
    Views
    101

    I had one this year giving symptoms similar to...

    I had one this year giving symptoms similar to that. The new aftermarket coil was the problem.
  3. Yes, speed and rpm's steadily increase 'til it's...

    Yes, speed and rpm's steadily increase 'til it's pinned to the bars. Many times, people install a new engine without fixing the root cause of the first failure. Don't ride any more until the issue is...
  4. Replies
    1
    Views
    73

    WTB - Parts Az quad parts has Kibblewhite valves for $25ea...

    Az quad parts has Kibblewhite valves for $25ea new. That's what I've been using.
  5. Replies
    5
    Views
    138

    Yes, Ultra 150's are quick. Depending on...

    Yes, Ultra 150's are quick. Depending on conditions, 63-66mph.
  6. Replies
    8
    Views
    192

    The SBN kits have parts for the 38, 40i, and 44. ...

    The SBN kits have parts for the 38, 40i, and 44. Yes, your 1100 has triple 38 with seperate fuel pump. The 760 has dual 44 with integrated fuel pump.
  7. Replies
    9
    Views
    129

    Set it on the AC scale at 200, yes on black and...

    Set it on the AC scale at 200, yes on black and purple (excitor coil). Crank it, looking to see how many volts it cranks out.
  8. Replies
    9
    Views
    129

    I think it will crank with just battery hooked up.

    I think it will crank with just battery hooked up.
  9. Replies
    1
    Views
    71

    Did you try running it with stop switch...

    Did you try running it with stop switch disconnected?
  10. Replies
    9
    Views
    129

    Most likely bad stator. What is the ac voltage...

    Most likely bad stator. What is the ac voltage output of that excitor coil while cranking?
  11. Replies
    1
    Views
    70

    Board is labeled by color, put the colored wires...

    Board is labeled by color, put the colored wires where they go.
  12. Replies
    5
    Views
    140

    It can be difficult to see fuel flowing.

    It can be difficult to see fuel flowing.
  13. Replies
    5
    Views
    140

    Check every cylinder individually after the...

    Check every cylinder individually after the engine is a bit warm. It should start on each cylinder individually on the trailer. If the one doesn't, then try swapping plugs or squirting a wee bit of...
  14. Replies
    6
    Views
    200

    That's not a great pic but you're looking for a...

    That's not a great pic but you're looking for a stamped "o" near the crank journals. And also on the rods near the caps. Then use the chart posted above. If the crank has a stamped "o" but the rod...
  15. The shield on my wife's Fxho is smoked and looked...

    The shield on my wife's Fxho is smoked and looked like what you describe. The cracks are inside the plastic, caused by the sun. I used a red scotchbrite to fully remove oxidation then buffed it out....
  16. Replies
    1
    Views
    71

    You'll need to open the electrical box and test...

    You'll need to open the electrical box and test for output voltage of the solenoid.
  17. Replies
    4
    Views
    117

    Crack both high speed sdjusters open to 1/2 turn....

    Crack both high speed sdjusters open to 1/2 turn. If the prblem goes away then you know it's related to fuel delivery or the engine sucking a bit of air through a bad seal or gasket.
  18. Thread: weird noise

    by Myself
    Replies
    5
    Views
    178

    Whining, whirring sound is almost always jet pump...

    Whining, whirring sound is almost always jet pump bearings. Pull it for inspection.
  19. Thread: weird noise

    by Myself
    Replies
    5
    Views
    178

    Can't tell anything from that vid. What kind of...

    Can't tell anything from that vid. What kind of noise?
  20. Replies
    5
    Views
    155

    I have also had to put a new iac on an stx15 for...

    I have also had to put a new iac on an stx15 for thse same symptoms.
  21. If everything else looked good then I'm guessing...

    If everything else looked good then I'm guessing a ring is stuck in the grooves.
  22. Replies
    5
    Views
    209

    After oil is pretty clean, just take it out and...

    After oil is pretty clean, just take it out and ride it for a good half hour. That's all I've ever done. You can run it at various throttles strapped to the trailer if you want to as well.
  23. Yes, there is always a bit of power to gain with...

    Yes, there is always a bit of power to gain with port cleanup. You will never notice a difference until you do a lot more modding.
  24. Did you pull the rings off the piston and clean...

    Did you pull the rings off the piston and clean them while it was apart?
  25. I agree, those are non maintenance items, replace...

    I agree, those are non maintenance items, replace when they quit.
Results 1 to 25 of 200
Page 1 of 8 1 2 3 4