Search

Type: Posts; User: Teme

Search: Search took 0.00 seconds.

  1. Replies
    2
    Views
    184

    View Post

    Well, I don’t think that it does really matter. Why larger hoses?

    The fuel system is pressurized and line connectors are 1/4” sized. Larger hoses might cause leakages with joints.

    By default...
  2. Replies
    4
    Views
    173

    Hi Rebuild is quite straight forward and need...

    Hi

    Rebuild is quite straight forward and need to be performed regular basis, I do it once a season. Use original rebuild kits.

    Here is good video https://youtu.be/S8zAqT_xaPE

    Check from...
  3. Replies
    2
    Views
    226

    Hi By my experience, carbs rebuild should make...

    Hi

    By my experience, carbs rebuild should make a difference. Fuel pump might leak or there is dirt in jets. That would explain why engine runs ‘fine’ when unloaded.
  4. View Post

    My engine’s first rebuild was after 120hrs too. 2 pistons were burned due the water in fuel. Since then I have been really strict with the fuel type. And flushed tank always before winter. For...
  5. View Post

    I’m located at Finland [emoji1787] so my recommendations might not work with your plans...

    Basically any race tuning workshop (dirt bike, snowmobile, etc) should have proper tools. Bore diameter...
  6. Common Reasons for zeizure are bad oil or bad oil...

    Common Reasons for zeizure are bad oil or bad oil injection. There is a oil block mod but I do not have it.
    Next common is water in fuel, if using fuel with high ethanol rate (>5%) it turns to water...
  7. What I did in similar situation was a new head...

    What I did in similar situation was a new head (repaired), oversized pistons and each cylinder bore drilling to new size at motocross engine shop (was the nearest with proper tools). They needed...
  8. Replies
    5
    Views
    478

    PM sent

    PM sent
  9. Replies
    6
    Views
    355

    Hi, Check and clean carbs. Could been too lean,...

    Hi,
    Check and clean carbs. Could been too lean, sounds like one cylinder was seizing due the heat. Possible damages can be checked by cylinder pressure test if no visible issues exist.

    Cheers,...
  10. Thread: 01 suv 1200

    by Teme
    Replies
    1
    Views
    303

    PM sent

    PM sent
  11. Replies
    2
    Views
    390

    Here is the wiring diagram for reference...

    Here is the wiring diagram for reference
    http://www.greenhulk.net/forums/attachment.php?attachmentid=437715&stc=1
  12. Did you check and clean reed valves between carbs...

    Did you check and clean reed valves between carbs and cylinders?
  13. Replies
    2
    Views
    390

    View Post

    Hi,
    Which one of wires could provide a continuous signal when ignition ON? My plan is to use it for GPS tracker.

    Regards,
    -Teemu
  14. Replies
    0
    Views
    415

    View Post

    Which wire can be used to detect when engine is running?
  15. Replies
    8
    Views
    5,535

    The issue was caused by fuel line restrictor and...

    The issue was caused by fuel line restrictor and leaking reeds. I removed restrictor and changed reeds to V-Force3 reeds. After carb tuning it works extremely fine, top speed 57mph
  16. Replies
    8
    Views
    5,535

    With stock air box I have set pop offs to 65psi,...

    With stock air box I have set pop offs to 65psi, however it didn't solve my issue.

    Engine does not accelerate properly from idle to full throttle unless performing smooth acceleration. I adjusted...
  17. Replies
    8
    Views
    5,535

    Thanks. Have to check pop off pressures next time...

    Thanks. Have to check pop off pressures next time I open carbs.

    Today I made quick test run and noticed that the issue exists during throttle pumping only if throttle is fully released in between....
  18. Replies
    8
    Views
    5,535

    SUV-1200 non-PV Carb tuning

    Hello

    Please advise with my issue.

    Engine runs and idling fine but bogging when pumping throttle few times from idle to full. However it doesn't die and becomes back to responsible after few...
Results 1 to 18 of 18