Search

Type: Posts; User: K447

Page 1 of 8 1 2 3 4

Search: Search took 0.36 seconds.

  1. Thread: Thermostat delete

    by K447
    Replies
    20
    Views
    384

    Not sure what you are talking about :smt102 ...

    Not sure what you are talking about :smt102

    The Polaris PWC engines are well cooled in the factory configuration. Overheating is just not a problem unless something is wrong or the cooling system...
  2. My guess is either the EMM has failed or somehow...

    My guess is either the EMM has failed or somehow the EMM signals to the two front ignition coil primaries are not actually arriving.

    Trace (ohm check) the ignition coil primary wires back to the...
  3. Welcome. The long front driveshaft just pulls...

    Welcome.

    The long front driveshaft just pulls straight out from the impeller nose. The shaft might be binding on the rubber o-ring that seals the splines or the splines might just be tight. It...
  4. Replies
    7
    Views
    134

    Well, perhaps idle on one cylinder was not quite...

    Well, perhaps idle on one cylinder was not quite the right description.

    If the Ficht engine will start and stay running on one cylinder but needs some throttle squeeze to stay running, that is...
  5. Thread: Thermostat delete

    by K447
    Replies
    20
    Views
    384

    View Post

    There is the ‘figure 8’ rubber perimeter seal, and there is a the rubber seal for the thermostat itself.

    http://greenhulk.net/forums/attachment.php?attachmentid=81236&d=1214106110
    ...
  6. Thread: Thermostat delete

    by K447
    Replies
    20
    Views
    384

    Is there a rubber ring around the thermostat rim?

    Is there a rubber ring around the thermostat rim?
  7. Do you have another EMM you could swap in for a...

    Do you have another EMM you could swap in for a test?
  8. What markings does it have? The MFI tachometer...

    What markings does it have?

    The MFI tachometer signal on Yellow wire comes from the stator charging circuit, same stator coil that charges the battery. If the charging coil is not working the...
  9. Well, what are the comparative wire colors on the...

    Well, what are the comparative wire colors on the aftermarket LR-505, which wire is ‘missing’?

    Are you sure it is a 505 module?
  10. The CDI module has nothing to do with the bilge...

    The CDI module has nothing to do with the bilge pump nor the voltage regulator. If the engine is running properly then the CDI is working.

    The LR-505 controls the bilge pump and voltage regulation...
  11. Replies
    11
    Views
    112

    Failure cause analysis can occur while the EMM is...

    Failure cause analysis can occur while the EMM is in for repair.

    Sometimes the Ficht EMM just has internal component failure(s) that can short circuit the stator output and create large amp flow....
  12. Which check valve is stuck closed, vacuum or...

    Which check valve is stuck closed, vacuum or pressure?

    You might try removing it and cleaning the valve with some medium grade solvent.

    Also inspect for possible vent blockage from a spider...
  13. Replies
    23
    Views
    976

    The 8K choice for Stage 1 PLUS may already be in...

    The 8K choice for Stage 1 PLUS may already be in there.
    I forget whether it got added as a 'standard' choice across all the SVHO models and years.

    There is a significant gain in engine power...
  14. Replies
    11
    Views
    112

    That suggests the EMM may/probably needs repair.

    That suggests the EMM may/probably needs repair.
  15. Replies
    11
    Views
    112

    None of that pre-mixed oil in the fuel will...

    None of that pre-mixed oil in the fuel will lubricate any part of the engine.
  16. Replies
    23
    Views
    976

    The requested tune gets electronically linked to...

    The requested tune gets electronically linked to your tune licence code (encoded to your ECU ‘VIN’).

    When the MaptunerX software (with your license already loaded) next connects online it...
  17. Replies
    23
    Views
    976

    You would buy and own the license. The code is...

    You would buy and own the license. The code is delivered electronically to you.

    The licence code is loaded onto the MaptunerX software at the shop and from there into their MaptunerX box. The...
  18. Replies
    11
    Views
    112

    Is the new stator genuine OEM or aftermarket?

    Is the new stator genuine OEM or aftermarket?
  19. Replies
    11
    Views
    112

    Welcome. If you dribble a tiny amount of fuel...

    Welcome.

    If you dribble a tiny amount of fuel down each of the throttle body air intakes, does it start and run for a few seconds?


    Note: Ficht engines MUST have the factory oil injection...
  20. Replies
    23
    Views
    976

    8000RPM limiter. Target RPM would be couple...

    8000RPM limiter.

    Target RPM would be couple hundred RPM below that, say 7850-ish.
    Target RPM is controlled by the impeller pitch. *

    At wide open throttle on smooth water the impeller pitch...
  21. Replies
    22
    Views
    261

    The hull wants to float when it is backed in far...

    The hull wants to float when it is backed in far enough to get the jet pump intake fully submerged.

    Unless the rear is strapped down it will drift side to side easily.

    And if you steer...
  22. Replies
    22
    Views
    261

    http://greenhulk.net/forums/showthread.php?t=29150...

    http://greenhulk.net/forums/showthread.php?t=291506&p=3117016&viewfull=1#post3117016

    Testing on the launch ramp...
  23. Replies
    23
    Views
    976

    If it is not listed in the tune list you can...

    If it is not listed in the tune list you can request a Stage 1 PLUS tune with 8000RPM limiter. I used the 8000 limit tune for a year or two, worked just fine.

    The 8000 limit tune provides...
  24. Replies
    22
    Views
    261

    The factory oil pump system is variable flow rate...

    The factory oil pump system is variable flow rate and is quite efficient with oil consumption. It will not excessively over-oil the engine unless something is wrong.

    What can happen with an engine...
  25. Ah, the vacuum relief (7052118) and pressure...

    Ah, the vacuum relief (7052118) and pressure release (7051015) check valves for the fuel tank venting.
    ...
Results 1 to 25 of 200
Page 1 of 8 1 2 3 4