Search

Where did you send them off to?

I have a 2000 GSX rfi that's running really poorly. Acts flooded almost, hard to start when warm. When full throttle was applied it just died. In about 30-45 mins of riding it used almost half a...

Well, the fuel pump was blowing bubbles and when I covered up the end of the fuel hose with my thumb it pulsed, rather than sucked. The pulse hose had a nice strong pulse. It's having fuel delivery...

Thanks! I took the diaphragms off, just was an idiot and pressurized through the pump. I recently rebuilt the carbs with a generic kit so I was trying to improve running. I know I can pressure test...

Thanks for the replys.

Does anyone know where to find a pump rebuild for a '97 SLT 700 keihin carb?

Fount this on Atlantic Jet Sports, but it looks like it's for a kawasaki CDK II.
Might that work or does someone...

I was having trouble getting my SLT 700 started after running a while (hot) and was having to use part throttle to keep it from dying (rebuilt carbs recently just to get it running). Tested pop off...

Ok, well that's one problem that shouldn't be there, thank you. It was a very wet mist/large drops that I could see coming out. I assume liquid in there could block the pulse pump pulsing and make...

Also, I pulled the pulse line off and cranked the motor to at least see if it had some pressure and some fuel was spraying out of the nipple on the bottom of the case. Is that normal? I assumed a...

No, the reeds were not inspected, I wasn't sure it that could cause this, I'll inspect those.

Compression isn't great 97pto 105 mag

Pulse hose is new, I changed it, feels good and hooked up to...

Recently bought a 1997 SLT 700 that wasn't running. Previous owner said it was having fuel problems, he hooked up an electric pump to solve the problem (horrible I know) and flooded the crankcase. ...

Thanks.

So the case doesn't have an actual gasket when I tear this thing down, it just uses rtv or better sealant?

I bypassed the fuel selector to narrow down the leaning issue as coming from air somewhere before the carb/pump or engine leak. I ran it from a glass jar of fuel directly to the pump/carb it still...

Engine ran away with no throttle applied for a bit and then died. Carbs were not adding fuel from the high jet as far as I could see. I think it might have been a lean runaway.
Mag piston is only...

Recently bought a '97 SLT 700, rebuilt carbs, added new pump diaphragm. Previous owner said it had a fuel starvation issue. Ran into that on the water after a throttle runaway, wouldn't draw fuel...